关于油炸锅的非正常测试

美好的未来

广东安规检测
有限公司提供：

小型摆管淋雨试验机

IPX5X6X7喷水试验机

1000L恒温恒湿箱

各种试验指现货

可程式恒温恒湿试验箱

水平垂直燃烧机

自动卷线器试验机

耐划痕试验机

各种灯头量规现货

灼热丝试验机现货

GB1002插头量规

IPX1-X7淋雨现货

IEC61347/UL935镇流器热试验箱

灯具防风罩

IK冲击试验机

UL498插头插座量规

VDE0620插头插座量规

稳定性试验台

家电温升测试角

针焰试验机现货

热电偶焊机现货

家电125mm试验指

E12灯头量规

无绳壶无绳电熨斗插拔寿命试验机

IEC60335试验指甲

各位高人
9 \$ y$ [4 U* g/ Y9 l        油炸锅依UL1083的要求来完成设计，请部非正常测试如何测试，请详细说明

往事如烟

ABNORMAL OPERATION TEST (DEEP FAT FRYERS/COOKER-FRYERS/FONDUES):
! k0 |1 e/ Z/ m
The appliance was placed in a test corner consisting of dull black painted fir plywood not less than 3/8 in. thick, having such width and height that the walls extended not less than 2 ft beyond the physical limits of the appliance.  The vertical walls met at a right angle.  A 12 inch deep simulated cabinet bottom, consisting of the same material as the walls, was placed 15 in. above the counter top.  The supporting surface consisted of softwood covered by two layers of white tissue paper.  The appliance was located as close to the walls as the construction would permit.  A 60 Hz source of supply was connected to the unit with an input equal to the largest value recorded during the Power Input Test performed previously.  A 3 A fuse was connected between dead metal parts of the unit and earth ground.  
& a0 G: Z% P$ i3 N  l: I+ Q
6 x& i6 R6 u9 {+ b# {/ @    After each of the following parts of the Abnormal Operation Test, the Leakage Current was measured through a 500 ohm resistor connected between an accessible part and ground as quickly as possible thereafter.
# Q; a) P6 j* a7 a
    Part 1 - The appliance was operated with fresh unused pure cold peanut oil at the recommended level, with the thermostat set to the position that gave maximum heat, and with the appliance initially at room temperature.  It was operated for a period of 7-1/2 hours, or until ultimate results were observed. The cover was not in place.

    Part 2 - Part 1 was repeated except with the oil drained from the appliance and leaving a residual film of oil behind.
- j6 e  e$ O9 q) u
* X) k# F0 P! t" z6 S    Part 3 - Part 1 was repeated with all temperature controls other than the temperature limiting device defeated.  The appliance was filled to the recommended level; the basket filled with French fry potatoes and the cover removed.
6 ^% a9 o5 _8 k6 |0 q
    Part 4 - Part 2 was repeated except with all temperature controls other than the limiting device defeated.